Lignite

Characteristics

Lignite is brownish-black in color and has a carbon content of 60–70 percent on a dry ash-free basis. However, its inherent moisture content is sometimes as high as 75 percent and its ash content ranges from 6–19 percent, compared with 6–12 percent for bituminous coal. As a result, its carbon content on the as-received basis (i.e., containing both inherent moisture and mineral matter) is typically just 25-35 percent.

The energy content of lignite ranges from 10 to on a moist, mineral-matter-free basis. The energy content of lignite consumed in the United States averages 15 MJ/kg, on the as-received basis. The energy content of lignite consumed in Victoria, Australia, averages 8.6 MJ/kg on a net wet basis.

Lignite has a high content of volatile matter which makes it easier to convert into gas and liquid petroleum products than higher-ranking coals. Its high moisture content and susceptibility to spontaneous combustion can cause problems in transportation and storage. Processes which remove water from brown coal reduce the risk of spontaneous combustion to the same level as black coal, increase the calorific value of brown coal to a black coal equivalent fuel, and significantly reduce the emissions profile of 'densified' brown coal to a level similar to or better than most black coals. However, removing the moisture increases the cost of the final lignite fuel.

Lignite rapidly degrades when exposed to air, in a process called slacking (or slackening).

Uses

Most lignite is used to generate electricity. However, small amounts are used in agriculture, in industry, and even, as jet, in jewelry. Its historical use as fuel for home heating has continuously declined and is now of lower importance than its use to generate electricity.

As fuel

Lignite is often found in thick beds located near the surface, making it inexpensive to mine. However, because of its low energy density, tendency to crumble, and typically high moisture content, brown coal is inefficient to transport and is not traded extensively on the world market compared with higher coal grades. It is often burned in power stations near the mines, such as in Poland's Bełchatów plant and Turów plant, Australia's Latrobe Valley and Luminant's Monticello plant and Martin Lake plant in Texas. Primarily because of latent high moisture content and low energy density of brown coal, carbon dioxide emissions from traditional brown-coal-fired plants are generally much higher per megawatt-hour generated than for comparable black-coal plants, with the world's highest-emitting plant being Australia's Hazelwood Power Station{{cite web |access-date=2008-10-02 |url-status=dead |archive-url=https://web.archive.org/web/20081013091310/http://www.wwf.org.au/news/n223/ |archive-date=2008-10-13

The German Democratic Republic relied extensively on lignite to become energy self-sufficient, and eventually obtained 70% of its energy requirements from lignite. Lignite was also an important chemical industry feedstock via Bergius process or Fischer-Tropsch synthesis in lieu of petroleum, which had to be imported for hard currency following a change in policy by the Soviet Union in the 1970s, which had previously delivered petroleum at below market rates. East German scientists even converted lignite into coke suitable for metallurgical uses (high temperature lignite coke) and much of the railway network was dependent on lignite either through steam trains or electrified lines mostly fed with lignite derived power. As per the table below, East Germany was the largest producer of lignite for much of its existence as an independent state.

In 2014, about 12 percent of Germany's energy and, specifically, 27 percent of Germany's electricity came from lignite power plants, while in 2014 in Greece, lignite provided about 50 percent of its power needs. Germany has announced plans to phase out lignite by 2038 at the latest. Greece has confirmed that the last coal plant will be shut in 2025 after receiving pressure from the European Union and plans to heavily invest in renewable energy.

Home heating

Lignite was and is used as a replacement for or in combination with firewood for home heating. It is usually pressed into briquettes for that use. Due to the smell it gives off when burned, lignite was often seen as a fuel for poor people compared to higher value hard coals. In Germany, briquettes are still readily available to end consumers in home improvement stores and supermarkets.

In agriculture {{anchor|in agriculture}}

An environmentally beneficial use of lignite is in agriculture. Lignite may have value as an environmentally benign soil amendment, improving cation exchange and phosphorus availability in soils while reducing availability of heavy metals, and may be superior to commercial K humates. Lignite fly ash produced by combustion of lignite in power plants may also be valuable as a soil amendment and fertilizer. However, rigorous studies of the long-term benefits of lignite products in agriculture are lacking.

Lignite may also be used for the cultivation and distribution of biological control microbes that suppress plant pests. The carbon increases the organic matter in the soil while the biological control microbes provide an alternative to chemical pesticides.

Leonardite is a soil conditioner rich in humic acids that is formed by natural oxidation when lignite comes in contact with air. The process can be replicated artificially on a large scale. The less matured xyloid (wood-shaped) lignite also contains high amounts of humic acid.

In drilling mud {{anchor|in industry}}

Reaction with quaternary amine forms a product called amine-treated lignite (ATL), which is used in drilling mud to reduce fluid loss during drilling.

As an industrial adsorbent

Lignite may have potential uses as an industrial adsorbent. Experiments show that its adsorption of methylene blue falls within the range of activated carbons currently used by industry.

In jewellery {{anchor|in jewelry}}

Jet is a form of lignite that has been used as a gemstone. The earliest jet artifacts date to 10,000 BCE and jet was used extensively in necklaces and other ornamentation in Britain from the Neolithic until the end of Roman Britain. Jet experienced a brief revival in Victorian Britain.

Geology

Lignite begins as partially decayed plant material, or peat. Peat tends to accumulate in areas with high moisture, slow land subsidence, and no disturbance by rivers or oceans – under these conditions, the area remains saturated with water, which covers dead vegetation and protects it from atmospheric oxygen. Otherwise, peat swamps are found in a variety of climates and geographical settings. Anaerobic bacteria may contribute to the degradation of peat, but this process takes a long time, particularly in acidic water. Burial by other sediments further slows biological degradation, and subsequent transformations are a result of increased temperatures and pressures underground.

Lignite forms from peat that has not been subjected to deep burial and heating. It forms at temperatures below 100 C, The most characteristic chemical change in the organic material during formation of lignite is the sharp reduction in the number of C=O and C-O-R functional groups.

Lignite deposits are typically younger than higher-ranked coals, with the majority of them having formed during the Tertiary period.

Extraction

Lignite is often found in thick beds located near the surface. Regulations in the United States and other countries require that land that is surface mined must be restored to its original productivity once mining is complete.

Strip mining of lignite in the United States begins with drilling to establish the extent of the subsurface beds. Topsoil and subsoil must be properly removed and either used to reclaim previously mined-out areas or stored for future reclamation. Excavator and truck overburden removal prepares the area for dragline overburden removal to expose the lignite beds. These are broken up using specially equipped tractors (coal ripping) and then loaded into bottom dump trucks using front loaders.

Once the lignite is removed, restoration involves grading the mine spoil to as close an approximation as practical of the original ground surface (Approximate Original Contour or AOC). Subsoil and topsoil are restored and the land reseeded with various grasses. In North Dakota, a performance bond is held against the mining company for at least ten years after the end of mining operations to guarantee that the land has been restored to full productivity. A bond (not necessary in this form) for mine reclamation is required in the US by the Surface Mining Control and Reclamation Act of 1977.

Resources and reserves

List of countries by lignite resources

Australia

The Latrobe Valley in Victoria, Australia, contains estimated reserves of some 65 billion tonnes of brown coal. The deposit is equivalent to 25 percent of known world reserves. The coal seams are up to 98 m thick, with multiple coal seams often giving virtually continuous brown coal thickness of up to 230 m. Seams are covered by very little overburden (10 to 20 m).

A partnership led by Kawasaki Heavy Industries and backed by the governments of Japan and Australia has begun extracting hydrogen from brown coal. The liquefied hydrogen will be shipped via the transporter Suiso Frontier to Japan.

North America

The largest lignite deposits in North America are the Gulf Coast lignites and the Fort Union lignite field. The Gulf Coast lignites are located in a band running from Texas to Alabama roughly parallel to the Gulf Coast. The Fort Union lignite field stretches from North Dakota to Saskatchewan. Both are important commercial sources of lignite.

Types ==

Lignite can be separated into two types: xyloid lignite or fossil wood, and compact lignite or perfect lignite.

Although xyloid lignite may sometimes have the tenacity and the appearance of ordinary wood, it can be seen that the combustible woody tissue has experienced a great modification. It is reducible to a fine powder by trituration, and if submitted to the action of a weak solution of potash, it yields a considerable quantity of humic acid. Leonardite is an oxidized form of lignite, which also contains high levels of humic acid.

Jet is a hardened, gem-like form of lignite used in various types of jewelry.

Production

– no data available |}

Gallery

File:Braunkohletagebau Schleenhain.jpg|Open-pit United Schleenhain coal mine in Saxony, Germany

References

References

1. "Coal explained". [[Energy Information Administration]].
2. (December 2018). "Lignite coal – health effects and recommendations from the health sector". Health and Environment Alliance.
3. Holdinghausen, Heike. "Gesundheit: Feiner Staub, großer Schaden". [[Heinrich Böll Stiftung]].
4. Kopp, Otto C. [https://www.britannica.com/science/lignite "Lignite"] {{Webarchive. link. (2019-06-03 in ''Encyclopædia Britannica'')
5. Ghassemi, Abbas. (2001). "Handbook of Pollution Control and Waste Minimization". CRC Press.
6. "Lignite". U.S. Energy Information Agency.
7. (July 2010). "Victoria, Australia: A principal brown coal province". Department of Primary Industries Melbourne.
8. George, A.M.. (1975). "State Electricity Victoria, Petrographic Report No 17.".
9. Perry, G.J.. "Paper R4.1". Coal Resources Conference, NZ 1987.
10. "End of generation at Hazelwood". Engie.
11. (2006-08-18). "The Greens Won't Line Up For Dirty Brown Coal In The Valley". Australian Greens Victoria.
12. (2004-05-28). "Greenpeace Germany Protests Brown Coal Power Stations". Environment News Service.
13. (3 November 2014). "How East Germany Cleaned Up Dirty Power". Springer Nature America, Inc..
14. (2009). "Liquid fuel revival". Chemistry and Industry.
15. (29 April 2015). "The history of energy in Germany". Total Foundation.
16. (2014-10-01). "Statistics on energy production in Germany 2014, Department of Energy (in german, lignite = "Braunkohle")".
17. "Interview zum Kohlekompromiss: "Damit ist es nicht getan"".
18. (13 August 2019). "Was der Kohlekompromiss für Deutschland bedeutet".
19. "Teurer Kohlekompromiss".
20. (26 January 2019). "Kommentar zum Kohleausstieg: Der Kohlekompromiss ist ein Meisterstück".
21. (26 April 2021). "Greece confirms last coal plant will be shut in 2025".
22. (18 May 2021). "Σκρέκας: Προετοιμάζουμε και σχεδιάζουμε την πράσινη πολιτική της χώρας | ΣΚΑΪ".
23. (1980). "Fuels and fuel technology : a summarized manual". Pergamon Press.
24. (July 1995). "Domestic lignite combustion as source of polychlorodibenzodioxins and -furans (PCDD/F)". Chemosphere.
25. "Briketts kaufen bei".
26. "Briketts kaufen bei".
27. "Braunkohlebriketts 10kg bei REWE online bestellen!".
28. "Briketts kaufen bei Bauhaus".
29. (November 2015). "Lignite amendment has limited impacts on soil microbial communities and mineral nitrogen availability". Applied Soil Ecology.
30. (March 2021). "Impact of biochar and lignite-based amendments on microbial communities and greenhouse gas emissions from agricultural soil". Vadose Zone Journal.
31. (28 October 2016). "Commercial Humates in Agriculture: Real Substance or Smoke and Mirrors?". Agronomy.
32. (September 2007). "Management of Lignite Fly Ash for Improving Soil Fertility and Crop Productivity". Environmental Management.
33. (2014). "Evaluating Lignite-Derived Products (LDPs) for Agriculture – Does Research Inform Practice?". EGU General Assembly Conference Abstracts.
34. (1984). "Lignite and stillage:carrier and substrate for application of fungal biocontrol agents to soil". Phytopathology.
35. "Youngs, R.W. & Frost, C.M. 1963. Humic acids from leonardite – a soil conditioner and organic fertilizer. Ind. Eng. Chem., 55, 95–99".
36. (3 November 2020). "Extraction of Fulvic Acid from Lignite and Characterization of Its Functional Groups". ACS Omega.
37. (1 December 2018). "The Optimum Types and Characteristics of Drilling Fluids Used During Drilling in The Egyption Western Desert". Journal of Petroleum and Mining Engineering.
38. (April 2011). "Characterisation of lignite as an industrial adsorbent". Fuel.
39. (2005). "Glossary of Geology". American Geological Institute.
40. "Venus figures from Petersfels".
41. Allason-Jones, Lindsay. (1996). "Roman Jet in the Yorkshire Museum". The Yorkshire Museum.
42. Muller, Helen. (1987). "Jet". Butterworths.
43. (2002). "Coal – A complex natural resource". U.S. Geological Survey Circular.
44. (June 1996). "FTIR study of the evolution of coal structure during the coalification process". Organic Geochemistry.
45. "Reclamation Process". BNI Coal.
46. "Mining Process". BNI Coal.
47. "Reclamation Bonds".
48. Department of Primary Industries, Victorian Government, Australia, ‘Victoria Australia: A Principle Brown Coal Province’ (Fact Sheet, Department of Primary Industries, July 2010).
49. (24 December 2021). "Kawasaki Heavy says liquefied hydrogen carrier departs Japan for Australia". Reuters.
50. (1995). "Chapter 1 The principal lignite deposits of North America". Coal Science and Technology.
51. Tan, Kim H.. (22 April 2003). "Humic Matter in Soil and the Environment: Principles and Controversies". CRC Press.
52. (2014). "Resources". [[World Coal Association]].
53. (2012). "Production of Lignite Coal". [[U.S. Energy Information Administration]].
54. "Energiestudie 2016 Tabellen".
55. Gordon, Richard. (1987). "World coal: economics, policies and prospects". Cambridge University Press.
56. (1 November 2016). "Deutschland ‒Rohstoffsituation 2015".
57. Appunn, Kerstine. (7 August 2018). "Germany's three lignite mining regions".