Ivanpah Solar Power Facility

Description

The Ivanpah system consists of three solar thermal power plants on 3,500 acre of public land near the California–Nevada border in the Southwestern United States. Initially it was planned with 440 MW gross on 4000 acre of land, but then downgraded by 12%. It is west of south Interstate 15, north of Ivanpah, California, and adjacent to the Mountain Pass mine, the United States' only source of rare-earth minerals. The facility is visible from the I-15, the adjacent Mojave National Preserve, the Mesquite Wilderness, and the Stateline Wilderness. It is also visible from the Primm Valley resort area to the northeast.

Fields of heliostat mirrors focus sunlight on receivers located on centralized solar power towers. The receivers generate steam to drive specially adapted steam turbines.

For the first plant, the largest-ever fully solar-powered steam turbine generator set was ordered, with a 123 MW Siemens SST-900 single-casing reheat turbine. Siemens also supplied instrumentation and control systems. The plants use BrightSource Energy's "Luz Power Tower 550" (LPT 550) technology which heats the steam to 550 °C directly in the receivers. The plants have no storage.

Final approval for the project was granted in October 2010. On October 27, 2010, Governor of California, Arnold Schwarzenegger, Interior Secretary Ken Salazar, and other dignitaries gathered in the Mojave Desert to break the ground for the construction.

The largest investor in the project was NRG Energy, a generating company based in Princeton, New Jersey. It contributed $300 million. The project also received an investment of $168 million from Google. In November 2011, Google announced that it would no longer invest in the facility due to the rapid decline of the price of photovoltaic systems. $90,000,000 in financing was provided through the EB-5 Investor Immigration program, managed in this case by CMB Regional Centers.

The project, which had a total cost of about $2.18 billion, received a $1.6 billion loan guarantee from the United States Department of Energy. The facility developed contracts to sell about two-thirds of the power it generated to the Pacific Gas and Electric Company (PG&E), and the rest to Southern California Edison (SCE). PG&E announced in 2025 that it was terminating its contracts subject to approval by regulators.

|File:Ivanpah Solar Power Facility Online.jpg|Ivanpah Solar Power Facility online |File:Ivanpah Solar Power Facility.jpg|Ivanpah's eastern tower online. Note the sunlight glare on either side of the boiler. |File:One of the three towers of the Ivanpah Solar Power Facility.jpg|One of the three towers of the Ivanpah Solar Power Facility |File:BrightSource Energy Luz Power Tower 550 at full load (installed at Ivanpah Stateline Solar Facility, Nipton, CA).JPG|A close-up of one of the boilers taken with very short exposure |File:Ivanpah Solar Towers.jpg|Solar towers in full operation |File:Ivanpah, USA.jpg|Satellite photo of Ivanpah (center)

Fossil fuel consumption

The plant burns natural gas each morning to commence operation. The Wall Street Journal reported, "Instead of ramping up the plant each day before sunrise by burning one hour's worth of natural gas to generate steam, Ivanpah needs more than four times that much." On August 27, 2014, the State of California approved Ivanpah to increase its annual natural gas consumption from 328000000 ft3 of natural gas, as previously approved, to 525000000 ft3. In 2014, the plant burned 868e9 BTU of natural gas emitting 46,084 metric tons of carbon dioxide, which is nearly twice the pollution threshold at which power plants and factories in California are required to participate in the state's cap and trade program to reduce carbon emissions.{{cite news | access-date =23 October 2015 | archive-url =https://web.archive.org/web/20151022223835/http://www.ocregister.com/articles/plant-688596-gas-energy.html | archive-date =22 October 2015 | url-status =live

The facility uses three Rentech Type-D water tube boilers and three night time preservation boilers. The California Energy Resources Conservation and Development Commission approved for each a stack "130 ft high and 60 inch in diameter" and consumption of 242500 ft3/h of fuel.

Economic impact

BrightSource estimated that the Ivanpah facility would provide 1,000 jobs at the peak of construction, 86 permanent jobs, and total economic benefits of $3 billion.

The project received a $1.6 billion loan guarantee from the United States Department of Energy. According to Synapse Energy Economics, the estimated construction cost for the facility of $5,561.00 per kW fell between that of coal and nuclear power plants.{{cite tech report |access-date=2014-03-28 |archive-url=https://web.archive.org/web/20140630144840/http://www.synapse-energy.com/Downloads/SynapsePaper.2008-07.0.Coal-Plant-Construction-Costs.A0021.pdf |archive-date=2014-06-30 |url-status=live |access-date=2014-03-28 |archive-url=https://web.archive.org/web/20140512131340/http://www.synapse-energy.com/Downloads/SynapsePaper.2008-07.0.Nuclear-Plant-Construction-Costs.A0022.pdf |archive-date=2014-05-12 |url-status=live

In November 2014, the facility's investors applied for a $539 million federal grant to finance their federal loan.

Performance

Contracted power-delivery performance of 640 GWh/year from Units 1 and 3 and 336 GWh from Unit 2 was met by 2017, following sharply reduced production in the first few years of operation, particularly in the start-up year of 2014.

In November 2014, the Associated Press reported that the facility was producing only "about half of its expected annual output". The California Energy Commission issued a statement blaming this on "clouds, jet contrails and weather". Performance improved in 2015 to about 650 GWh. However, NRG Energy said in its November quarterly report that Ivanpah would likely not meet its contractual obligations to provide power to PG&E during the year, raising the risk of default on its Power Purchase Agreement. PG&E had a contract to receive 640 GWh/year from Units 1 and 3, while SCE was supposed to receive 336 GWh from Unit 2, at a price of about $200/MWh (20¢/kWh). In March 2016, PG&E agreed not to declare the plant in default for at least four months in return for an undisclosed sum from the owners.

In June 2015, The Wall Street Journal reported, "15 months after starting up, the plant is producing just 40% of [its expected more than a million megawatt-hours of electricity each year], according to data from the U.S. Energy Department." Performance improved dramatically in the second year. CleanTechnica reported with respect to units 1 and 3 that "in 2015, PG&E customers received about 97% of Ivanpah's contracted electrons, which is a massive improvement over its first year".

By 2017, due to improvements, the plant was meeting the contract output requirements.

The steam plant was designed for 28.72% gross efficiency. The local irradiance near the area is about 7.4 kWh/m2/day (annual average) for a total solar energy flow in the visible spectrum of 2.717 MWh/m2 yearly.

One heliostat mirror is a 75.6 ft2 reflecting surface,{{cite web |access-date=18 March 2014 |archive-url=https://web.archive.org/web/20140318092410/http://www.energy.ca.gov/sitingcases/ivanpah/ |archive-date=18 March 2014 |url-status=live

May 2016 fire

On May 19, 2016, a small fire was reported when misaligned mirrors reflected sunlight into a level of Unit 3 tower not designed to collect power, requiring the tower to shut down for repairs. As another of the three power-generating units was already offline for scheduled maintenance, the plant was left with only one third of its installation functional. Unit 3 resumed operation on June 8, 2016. All three units were back in operation by June 20, 2016. Solar thermal electricity production in California peaked at 703 MW on that day, up from 452 MW on June 7 when two units were offline.

Awards

In August 2014, Ivanpah was awarded the "Plant of the Year" award from Power magazine. In February 2012, Ivanpah was awarded the CSP (Concentrating Solar Power) Project of the Year by Solar Power Generation USA.

Environmental impacts

The Ivanpah installation was estimated, before operations started, to reduce carbon dioxide emissions by more than 400,000 tons annually. It was designed to minimize impacts on the natural environment compared to some photovoltaic solar facilities because the use of heliostats does not require as much grading of the land. The project was built on ecologically intact desert habitat. The facility was fenced off to keep out some terrestrial wildlife. However, birds faced the risk of collision with the heliostat mirrors or from burning in solar flux created by the mirror field.

In 2012, the National Parks Conservation Association (NPCA) issued a report on the project, citing water concerns, damage to visual resources, and impacts on important desert species. To conserve scarce desert water, LPT 550 uses air-cooling to convert steam back into water. Compared to conventional wet-cooling, this results in a 90 percent reduction in water usage. The water is then returned to the boiler in a closed process.

Another potential issue is the effect of mirror glare on airplane pilots. Additionally, "the power towers have 'receiver units' at their top on which the mirror fields focus their reflected light. During operation, these receiver units become extremely hot, such that they glow and appear brightly lit. ... Because they are high above the ground, these glowing receiver units will be a visible distraction to persons at many of the KOPs [Key Observation Points], including travelers utilizing I-15."

According to the State of California Energy Resources Conservation and Development Commission Opening Briefs regarding this project, "the project itself is visually imposing. It would cover roughly 4,000 acres, most of which would be covered with mirror fields. The panoramic expanse of mirror arrays would present strong textural contrast with the intact, natural character of the desert floor [and] would rise to a height of roughly 459 ft; an additional 10 to above that height would consist of lighting to meet Federal Aviation Administration (FAA) requirements."

Desert tortoise

The Ivanpah Solar power project was built on 6 mi2 of public land in the south central Mojave Desert. Project construction was temporarily halted in the spring of 2011 due to the suspected impacts on desert tortoises. Construction resumed when the United States Fish and Wildlife Service (USFWS) found the project was not likely to jeopardize the endangered desert tortoise. BrightSource also installed fencing to keep wildlife out of the area. In 2010, the project was scaled back from the original 440 MW design, to avoid building on the habitat of the desert tortoise.

Many desert tortoises found on the site were relocated to other parts of the Mojave Desert. However, environmentalists raised concerns that relocated tortoises were more likely to die due to the stresses involved.

Birds

During the trial of the plant in September 2013, thirty-four (34) dead birds were found at the plant. Fifteen had heavily burned feathers, which staff at the plant referred to as "streamers" because they were burned in flight by the intense radiation from the heliostat mirrors. From February through June 2014, a team of biologists monitoring the number of bird deaths reported a total of 290.

In April 2014, the USFWS reported that 141 dead birds, including peregrine falcon, barn owl and yellow-rumped warbler had been collected at Ivanpah in October 2013. Forty-seven of the birds' deaths were attributed to solar flux. According to a report by the Associated Press, "Ivanpah might act as a 'mega-trap' for wildlife, with the bright light of the plant attracting insects, which in turn attract insect-eating birds that fly to their death in the intensely focused light rays." Bird kill mitigation strategies were considered, including proven, environmentally safe technologies such as avian radars and LRADs to keep birds away from the site, covering ponds to discourage waterbirds from loitering, and clearing additional land around the plant to make it less attractive and more visible to birds in flight.{{Cite web | access-date = 2014-12-07 | archive-url = https://web.archive.org/web/20141224042933/http://spectrum.ieee.org/energywise/green-tech/solar/ivanpah-solar-plant-turns-birds-into-smoke-streamers | archive-date = 2014-12-24 | url-status = live | access-date = 2014-12-07 | archive-url = https://web.archive.org/web/20141226113505/http://docketpublic.energy.ca.gov/PublicDocuments/09-AFC-07C/TN202538_20140623T154647_Exh_3107_Kagan_et_al_2014.pdf | archive-date = 2014-12-26 | url-status = live

In April 2015 The Wall Street Journal reported that "biologists working for the state estimated that 3,500 birds died at Ivanpah in the span of a year, many of them burned alive while flying through a part of the solar installment where air temperatures can reach 1,000 degrees Fahrenheit [540 °C]".

In late 2015, Brightsource released the results of the first full year monitoring bird and bat deaths at the Ivanpah solar plant. The company reported that during a year of study supervised by the California Division of Wildlife, the number of observed bird deaths, adjusted upward to account for inefficiencies of the carcass-counting, were around 3,500 bird deaths per year caused by the Ivanpah solar plant. The Ivanpah plant took steps to further reduce bird deaths.

The initial reports of high avian casualties have been disputed ever since initial reports surfaced. In September 2014, for example, Renewable Energy World suggested "With its claim of 28,000 dead birds from Ivanpah, the Associated Press syndicated a story, spreading alarm about concentrated solar power (CSP) plants, which was not grounded in facts, but on one opponent's speculation."

In September 2016, federal biologists said about 6,000 birds die from collisions or immolation annually while chasing flying insects around the facility's towers.

Ivanpah was covered in the 2019 documentary Planet of the Humans.

Production

Ivanpah Solar electric production is as follows (in megawatt-hours, MWh).

Ivanpah 1 (126 MW gross)

Ivanpah 2 (133 MW gross)

Ivanpah 3 (133 MW gross)

Ivanpah total (392 MW gross)

Ivanpah was advertised as designed to produce 940,000 MWh of electricity per year, based on its nameplate capacity and assumed capacity factor. In its second year of operation, Ivanpah's production of 653,122 MWh of net electricity was 69.5 percent of this value, ramping up from 44.6 percent in the first year. The commissioning of a new thermal plants requires up to four years to achieve 100% operating level, from the first grid connection to full production.{{cite web |title=EuroTrough Helped Cut Ramp-Up Time of China's 100 MW Urat CSP |url=https://www.solarpaces.org/eurotrough-cut-ramp-up-in-china-100-mw-urat-csp%E2%80%A8

Ivanpah total annual production

Fossil fuel use

Ivanpah Solar's use of gas is as follows, expressed in million British thermal units (Btu) as reported. For comparison to the above charts, 1 MWh is about 3.4 million Btu.

Ivanpah 1

Ivanpah 2

Ivanpah 3

Ivanpah total

NR = Not reported

n/a = Not available

In popular culture

The Ivanpah Solar Power Facility served as inspiration for the HELIOS One solar power plant's physical appearance in the 2010 videogame Fallout: New Vegas.

The facility inspired American rock band The Fray to name their 2014 album Helios. The album art is an aerial photograph of the plant, which also features in the lyric video for Love Don't Die.

References

References

1. Overton, Thomas W.. (August 2014). "Ivanpah Solar Electric Generating System Earns ''POWER''{{'}}s Highest Honor".
2. Michael R. Blood and Brian Skolof, [http://bigstory.ap.org/article/huge-thermal-plant-opens-solar-industry-grows "Huge thermal plant opens as solar industry grows"] {{webarchive. link. (2014-02-22 , [[Associated Press]], February 13, 2014.)
3. (May 22, 2013). "Update from Ivanpah – May 2013".
4. (2017-06-01). "Loan Programs Office: IVANPAH". [[US Department of Energy]].
5. "Ivanpah Solar Electric Generating System". [[National Renewable Energy Laboratory]] (NREL).
6. Trabish, Herman. (2014-02-13). "Ivanpah: World's Biggest Solar Power Tower Project Goes On-Line - But will more concentrated solar power follow?". [[Greentech Media]].
7. Paddison, Laura. (February 13, 2025). "This alien-like field of mirrors in the desert was once the future of solar energy. It's closing after just 11 years". CNN.
8. (5 December 2025). "Ivanpah solar plant off Interstate 15 to remain open".
9. [https://www.kcet.org/socal-focus/cities-and-landmarks-the-etymology-of-the-california-desert KCET - Cities and Landmarks, the Etymology of the California Desert]
10. "Ivanpah Solar Electric Generating System Tower 2 - the Skyscraper Center".
11. "Brightsource Ivanpah".
12. (September 24, 2013). "Business Wire: Ivanpah Solar Electric Generating System Reaches 'First Sync' Milestone". Businesswire.com.
13. (26 September 2013). "World largest solar thermal plant syncs to the grid". [[IEEE]].
14. link. (2016-01-29 , NRG press release, February 13, 2014.)
15. (2010-10-28). "Solar energy plant in California gets new partner in NRG". [[PennWell Corporation]].
16. Wald, Matthew. (November 28, 2011). "Google Pulls the Plug on a Renewable Energy Effort". The New York Times.
17. Woody, Todd. (February 11, 2010). "BrightSource Alters Solar Plant Plan to Address Concerns Over Desert Tortoise". [[The New York Times]].
18. (2025-02-02). "11 years after a celebrated opening, massive solar plant faces a bleak future in the Mojave Desert - The Nevada Independent". The Nevada Independent.
19. Haas, Greg. (Dec 9, 2025). "Ivanpah Solar Project at Nevada-California border lives on as regulators reject plan to shut it down".
20. (13 February 2025). "Older Ivanpah Solar Plant in California Will Close Units, as Tech Shifts". [[Engineering News-Record]].
21. Walsh, Bryan. (24 June 2013). "Tower of Power".
22. (1 April 2010). "Docket No. 07-AFC-5: Energy Commission Staff's Opening Brief". [[California Energy Commission]].
23. link. (2017-12-13)
24. Siemens. "Energy efficiency. Rethinking the energy system here in the U.S.". Usa.siemens.com.
25. [http://www.renewableenergyworld.com/rea/news/article/2009/09/brightsource-bechtel-partner-on-440-mw-ivanpah-csp-project BrightSource & Bechtel Partner on 440-MW Ivanpah CSP Project] {{Webarchive. link. (2013-10-24 ''Renewable Energy World'', September 10, 2009.)
26. "[http://www.energy.ca.gov/siting/meetings/2010-01-22_meeting/presentations/BrightSource_Energy-Ivanpah_Project_Overview_2010-01-22.pdf] {{Webarchive. link. (2017-02-15", page 8)
27. (2014-11-20). "Concentrating Solar Power Projects - Ivanpah Solar Electric Generating System. Concentrating Solar Power. NREL".
28. [http://www.businessgreen.com/business-green/news/2271240/brightsource-secures-final BrightSource secures final approval for Ivanpah solar project] {{Webarchive. link. (2010-10-11 , BusinessGreen.com staff, BusinessGreen, 08 Oct 2010)
29. Sadanand, Tejal. (April 12, 2011). "Google goes green, invests $168 million in Ivanpah Solar power". [[International Business Times]].
30. link. (2012-06-15 ''Reve'', 24 Nov 2011. Accessed: 25 Nov 2011.)
31. [http://www.google.org/rec.html Google Renewable Energy Cheaper than Coal (RE<C)] {{webarchive. link. (2013-06-29 , [[Google]]. Accessed: 30 November 2011.)
32. "CMB - EB5 Visa".
33. Wesoff, Eric. (April 25, 2011). "BrightSource Files for $250M IPO: A Closer Look". Greentech Media.
34. Electric Power Daily. (12 April 2011). "DOE finalizes $1.6 billion Ivanpah solar loan". Platts.
35. Mufson, Steven. (February 23, 2010). "Solar power project in Mojave Desert gets $1.4 billion boost from stimulus funds". [[Washington Post]].
36. Gupta, Poornima. (February 22, 2010). "California solar project gets $1.4 bln US guarantee". [[Reuters]].
37. Blood, Michael R.. (January 30, 2025). "11 years after a celebrated opening, massive solar plant faces a bleak future in the Mojave Desert".
38. (12 June 2015). "High-Tech Solar Projects Fail to Deliver". Wall Street Journal.
39. [http://docketpublic.energy.ca.gov/PublicDocuments/07-AFC-05C/TN203064_20140915T132932_ISEGS_Order_Approving_Petition_to_Amend.pdf Approved petition] {{Webarchive. link. (2015-06-22 Docketpublicenergy.ca.gov, (PDF))
40. [http://www.physics.uci.edu/~silverma/actions/HouseholdEnergy.html Household energy] {{Webarchive. link. (2015-10-31 Physics UCI.)
41. Danko, Pete. (June 17, 2015). "Ivanpah Solar Production Up 170% in 2015". Breaking Energy.
42. "ORDER APPROVING a Petition to Modify SOLAR PARTNERS, LLC : Air Quality Conditions of Certification".
43. Zook, David. (November 16, 2009). "County Supervisor, Concerned by BrightSource Mega Solar Project Impacts, Calls for Full Review". Best Syndication News.
44. (11 April 2011). "DOE Finalizes $1.6 Billion Loan Guarantee for BrightSource Energy". U.S. Department of Energy.
45. La Jeunesse, William. (November 8, 2014). "World's largest solar plant applying for federal grant to pay off federal loan". Fox News.
46. (1 February 2017). "NRG's Massive California Solar Plant Finally Making Enough Power". Bloomberg.com.
47. link. (2016-01-29 , Associated Press, November 17, 2014)
48. Danko, Pete. (December 15, 2015). "Ivanpah Solar Project Faces Risk of Default on PG&E Contracts". [[KQED Inc..
49. Danelski, David. (March 17, 2016). "PUC gives Ivanpah plant operators more time to increase output". [[The Press-Enterprise]].
50. (12 June 2015). "High-Tech Solar Projects Fail to Deliver". Wall Street Journal.
51. (27 April 2016). "How Ivanpah Raised Its Performance In Its Second Year".
52. "U.S. Solar Radiation Resource Maps". NREL.
53. "Ivanpah Solar Electric Generating Station (ISEGS) Case Study". CleanEnergy ACTION PROJECT.
54. (30 January 2014). "Ivanpah Solar Project Quietly Goes Online – Or Does It?". KCET.
55. Staff. (19 May 2016). "Mirrors blamed for fire at world's largest solar plant". The Big Story.
56. "Renewables Watch for Operating Day: Monday, June 20, 2016".
57. "Renewables Watch for Operating Day: Tuesday, June 07, 2016".
58. (August 2014). "PLANT OF THE YEAR: Ivanpah Solar Electric Generating System Earns POWER's Highest Honor". Power.
59. (February 22, 2012). "The Ivanpah solar energy project named Concentrating Solar Power project of the year". REVE.
60. Lewis, Judith. (4 May 2009). "As the climate warms, environmentalists square off over Big Solar's claim to the Mojave Desert". High Country News.
61. "California Energy Commission". California Energy Commission.
62. "Avian & Bat Monitoring Plan". California Energy Commission.
63. DuHamel, Jonathan. (22 August 2014). "Ivanpah solar plant wants to burn more natural gas". Arizona Daily Independent.
64. Danelski, David. (April 16, 2015). "SOLAR POWER: Inland plants boost state to No. 1". [[The Press-Enterprise]].
65. "Ivanpah Temporary Suspension Notice". Federal Government.
66. link. (March 12, 2013)
67. California Energy Commission. "Final Staff Assessment of the Ivanpah Solar Electric Generating System". CEC.
68. Danelski, David. (8 October 2011). "First displaced tortoise released". Press-Enterprise.
69. Basin and Range Watch. "Desert Tortoise Recovery: Science and Politics Clash".
70. Kaufmann, K.. (2013-11-13). "Palen project raises concerns across Coachella Valley". mydesert.com.
71. "Preventing Bird Deaths at Solar Power Plants, Part 1". Renewable Energy World.
72. "Palen Solar Power Project - Compliance". Docketpublic.energy.ca.gov.
73. (18 August 2014). "Emerging solar plants in Mojave Desert scorch birds in mid-air". San Bernardino County Sun.
74. K Kaufmann. (7 April 2014). "Birds going up in smoke at Ivanpah solar project". The Desert Sun.
75. Kraemer, Susan. (2015-04-16). "One Weird Trick Prevents Bird Deaths At Solar Towers".
76. Sweet, Cassandra. (June 12, 2015). "High-Tech Solar Projects Fail to Deliver". [[Wall Street Journal]].
77. Peter Fairley, [https://spectrum.ieee.org/reassessing-bird-deaths-from-solar-power-towers Solar towers don't seem to be the bird-destroyers once thought], ''IEEE Spectrum'', 2 Nov. 2015.
78. Sahagun, Louis. (September 2, 2016). "This Mojave Desert solar plant kills 6,000 birds a year. Here's why that won't change any time soon". [[Los Angeles Times]].
79. Kraemer, Susan. (3 September 2014). "For the Birds: How Speculation Trumped Fact at Ivanpah". renewableenergyworld.com.
80. Zerkel, Eric. (19 August 2014). "New Solar Power Plants are Incinerating Birds". [[The Weather Channel]].
81. Sahagun, Louis (2 september 2016). [http://www.latimes.com/local/california/la-me-solar-bird-deaths-20160831-snap-story.html This Mojave Desert solar plant kills 6,000 birds a year. Here's why that won't change any time soon] {{Webarchive. link. (2016-09-05 , ''LA Times''. Retrieved 25 Nov. 2016.)
82. (March 2015). "Ivanpah". Loan Programs Office (LPO), [[United States Department of Energy.
83. (September 7, 2019). "HELIOS One and El Dorado Dry Lake". The Lucky Thirty Kate.
84. "Promoting Clean, Renewable Energy: Investments in Wind and Solar".