.204 Ruger

Characteristics

The .204 Ruger was developed from the .222 Remington Magnum, which has the second-largest case capacity in the family that began with the .222 Remington. Only the European 5.6×50mm Magnum is larger, which itself is a lengthened version of the .222 Remington Magnum. The .222 Remington Magnum provides about 5% more usable (below the neck) case capacity than the most popular member of the family, the NATO 5.56×45mm (.223 Remington). To make the .204 Ruger, the .222 Remington Magnum case was necked down to .204 inches (5 mm) and its shoulder moved forward and angle increased to 30 degrees. Bullets available in .204 caliber range from 24 to 55 grains (1.55 to 3.56 g). The Hornady factory load is listed at 4,225 ft/s (1288 m/s) with a 32 gr bullet. To achieve these velocities, the factory uses a proprietary powder composition known internally as SMP746, specially formulated by Primex, and, as of 2013, not available to handloaders. The propellant features a de-coppering agent (bismuth pellets) that helps prevent fouling. Reloading data from Hornady, using commercially available powders, indicate velocity peaking at just under 4200 ft/s with the 32 gr bullet in longer barrels.

Development

The .204 Ruger was the second Ruger-named cartridge produced by a partnership between Ruger and Hornady, the first being the big bore .480 Ruger revolver cartridge introduced in 2003 for the Super Redhawk. With the backing of a major gunmaker and a major ammunition company, the round was an instant success, with other ammunition makers and firearms makers quickly adding the new chambering. Ruger's initial offerings included the bolt action Model 77 MKII, and the single shot Ruger No. 1, and Hornady offered loadings with 30 and bullets.

The .204 Ruger has proven to be a very accurate and efficient cartridge: an early tester reported 1/2 MOA groups at 100 yards with the Hornady loads and a Ruger No. 1 varmint rifle. The first cartridge in the family, the .222 Remington, was a top benchrest shooting cartridge for many years after its introduction.

The .204 Ruger was intended primarily for varmint rifles, which require bullets with flat trajectories but not much mass or kinetic energy. The .204 was "splitting the difference" between the popular .224 varmint rounds such as the .220 Swift and .22-250 Remington, and the tiny .172 caliber rounds such as the .17 Remington and the .17 HMR. The resulting cartridge provides somewhat higher velocities than any of these, giving a maximum point blank range of more than 270 yards.

Velocity

Ruger's claim to being the velocity king with the .204 was based on two points.

First, no other high-performance .20 caliber cartridge was commercially produced. Second, the ammunition used to achieve the 4,225 ft/s was available only from Hornady using a special powder not available to the general public.

Handloaders typically achieve velocities more in the area of 4100 ft/s using a 32 gr bullet. Handloads using 40 gr bullets in other commercial cartridges such as the .22-250 Remington also achieve velocities similar to those of the .204 Ruger. The advantage of the .204 Ruger is that it achieves these velocities with less powder, less recoil, and less heat than the larger cartridges. The .204 Ruger has a maximum range of approximately 500 yd. Hornady now offers a 24-grain lead free cartridge that claims 4,400 ft/s from a 26-inch barrel. However, Hornady's 35 gr NTX .22-250 claims 4,450 ft/s from a 24-inch barrel.

References

References

1. "Hornady".
2. [http://www.norma.cc/en/Products/ Norma product catalog]
3. (26 November 2021). "204 Ruger {{!}} Lynx Defense".
4. "20 caliber cartridge guide, .204 Ruger".
5. Harvey, Nick. (4 October 2017). "Considering a 204 Ruger".
6. "20 Cal 55 Grain Match Grade Long Range BT Varmint".
7. Barnes, Frank C. (2016). "[[Cartridges of the World]]". [[Krause Publications]].
8. [http://www.chuckhawks.com/204_ruger.htm .204 Ruger by Chuck Hawks]
9. [http://data.hodgdon.com/cartridge_load.asp .204 load data at Hodgdon] {{webarchive. link. (11 November 2007)
10. "Hornady Manufacturing Company :: Ammunition :: Rifle :: Choose by Caliber :: 204 Ruger :: 204 Ruger 24 gr NTX Superformance".