Explorer 1

Background

The U.S. Earth satellite program began in 1954 as a joint U.S. Army and U.S. Navy proposal, called Project Orbiter, to put a scientific satellite into orbit during the International Geophysical Year. The proposal, using a military Redstone missile, was rejected in 1955 by the Eisenhower administration in favor of the Navy's Project Vanguard, using a booster advertised as more civilian in nature. Following the launch of the Soviet satellite Sputnik 1 on 4 October 1957, the initial Project Orbiter program was revived as the Explorer program to catch up with the Soviet Union.

Explorer 1 was designed and built by the Jet Propulsion Laboratory (JPL), while a Jupiter-C rocket was modified by the Army Ballistic Missile Agency (ABMA) to accommodate a satellite payload; the resulting rocket known as the Juno I. The Jupiter-C design used for the launch had already been flight-tested in nose cone reentry tests for the Jupiter intermediate-range ballistic missile (IRBM) and was modified into Juno I. Working closely together, ABMA and JPL completed the job of modifying the Jupiter-C and building Explorer 1 in 84 days. However, before work was completed, the Soviet Union launched a second satellite, Sputnik 2, on 3 November 1957. The U.S. Navy attempted to put the first U.S. satellite into orbit but failed with the launch of the Vanguard TV-3 on 6 December 1957.

Spacecraft

Explorer 1 was designed and built by California Institute of Technology's JPL under the direction of Dr. William Hayward Pickering. It was the second satellite to carry a mission payload (Sputnik 2 was the first).

The total mass of the satellite was 13.97 kg, of which 8.3 kg were instrumentation. In comparison, the mass of the first Soviet satellite Sputnik 1 was 83.6 kg. The instrument section at the front end of the satellite and the empty scaled-down fourth-stage rocket casing orbited as a single unit, spinning around its long axis at 750 revolutions per minute.

Data from the scientific instruments was transmitted to the ground by two antennas. A 60 milliwatt transmitter fed a dipole antenna consisting of two fiberglasses slot antennas in the body of the satellite operating on 108.03 MHz, and four flexible whips forming a turnstile antenna were fed by a 10 milliwatt transmitter operating on 108.00 MHz.

Because of the limited space available and the requirements for low weight, the payload instrumentation was designed and built with simplicity and high reliability in mind, using germanium and silicon transistors in its electronics. A total of 20 transistors were used in Explorer 1, plus additional ones in the Army's micrometeorite amplifier. Electrical power was provided by mercury chemical batteries that made up approximately 40% of the payload weight.

The external skin of the instrument section was sandblasted stainless steel with white stripes. Several other color schemes had been tested, resulting in backup articles, models, and photographs showing different configurations, including alternate white and green striping and blue stripes alternating with copper. The final color scheme was determined by studies of shadow–sunlight intervals based on firing time, trajectory, orbit and inclination.

Science payload

The Explorer 1 payload consisted of the Iowa Cosmic Ray Instrument without a tape data recorder which was not modified in time to make it onto the spacecraft. The real-time data received on the ground was therefore very sparse and puzzling showing normal counting rates and no counts at all. The later Explorer 3 mission, which included a tape data recorder in the payload, provided the additional data for confirmation of the earlier Explorer 1 data.

The scientific instrumentation of Explorer 1 was designed and built under the direction of Dr. James Van Allen of the University of Iowa containing:

• Anton 314 omnidirectional Geiger–Müller tube, designed by Dr. George H. Ludwig of Iowa's Cosmic Ray Laboratory, to detect cosmic rays. It could detect protons with E30 MeV and electrons with E3 MeV. Most of the time the instrument was saturated;

• Five temperature sensors (one internal, three external and one on the nose cone);

• Acoustic detector (crystal transducer and solid-state amplifier) to detect micrometeorite (cosmic dust) impacts. It responded to micrometeorite impacts on the spacecraft skin in such a way that each impact would be a function of mass and velocity. Its effective area was 0.075 m2 and the average threshold sensitivity was 2.5 g cm/s;

• Wire grid detector, also to detect micrometeorite impacts. It consisted of 12 parallel connected cards mounted in a fiberglass supporting ring. Each card was wound with two layers of enameled nickel alloy wire with a diameter of 17 μm (21 μm with the enamel insulation included) in such way that a total area of 1 xx was completely covered. If a micrometeorite of about 10 μm impacted, it would fracture the wire, destroy the electrical connection, and thus record the event.

Flight

After a jet stream-related delay on 28 January 1958, at 03:47:56 GMT on 1 February 1958 the Juno I rocket was launched, putting Explorer 1 into orbit with a perigee of 358 km and an apogee of 2550 km having a period of 114.80 minutes, and an inclination of 33.24°. Goldstone Tracking Station could not report after 90 minutes as planned whether the launch had succeeded because the orbit was larger than expected. At about 06:30 GMT, after confirming that Explorer 1 was indeed in orbit, a news conference was held in the Great Hall at the National Academy of Sciences in Washington, D.C. to announce it to the world.

The original expected lifetime of the satellite before orbital decay was three years. Mercury batteries powered the high-power transmitter for 31 days and the low-power transmitter for 105 days. Explorer 1 stopped transmission of data on 23 May 1958, when its batteries died, but remained in orbit for more than 12 years. It reentered the atmosphere over the Pacific Ocean on 31 March 1970 after more than 58,400 orbits.

Results

Explorer 1 changed rotation axis after launch. The elongated body of the spacecraft had been designed to spin about its long (least-inertia) axis but refused to do so, and instead started precessing due to energy dissipation from flexible structural elements. Later it was understood that on general grounds, the body ends up in the spin state that minimizes the kinetic rotational energy for a fixed angular momentum (this being the maximal-inertia axis). This motivated the first further development of the Eulerian theory of rigid body dynamics after nearly 200 years – to address this kind of momentum-preserving energy dissipation.

Sometimes the instrumentation reported the expected cosmic ray count (approximately 30 counts per second) but other times it would show a peculiar zero counts per second. The University of Iowa (under James Van Allen) observed that all of the zero counts per second reports were from an altitude of more than 2000 km over South America, while passes at 500 km would show the expected level of cosmic rays. Later, after Explorer 3, it was concluded that the original Geiger counter had been overwhelmed ("saturated") by strong radiation coming from a belt of charged particles trapped in space by the Earth's magnetic field. This belt of charged particles is now known as the Van Allen radiation belt. The discovery was considered to be one of the outstanding discoveries of the International Geophysical Year.

The acoustic micrometeorite detector detected 145 impacts of cosmic dust in 78,750 seconds. This calculates to an average impact rate of 8.0−3 impacts per second per square meter, or 29 impacts per hour per square meter, over the twelve-day period.

Legacy

Explorer 1 was the first of the long-running Explorers program. Four follow-up satellites of the Explorer series were launched by the Juno I launch vehicle in 1958. Of these, Explorer 3 and 4 were successful, while Explorer 2 and 5 failed to reach orbit. The final flight of the Juno I booster, the satellite Beacon-1, also failed. The Juno I vehicle was replaced by the Juno II launch vehicle in 1959.

A follow-up to the first mission, Explorer-1 Prime Unit 2, was successfully launched aboard a Delta II launch vehicle in late October 2011. The Prime was built using modern satellite construction techniques. The orbiting satellite was a backup, because the initial Explorer-1 Prime, launched on 4 March 2011, did not reach orbit due to a launch vehicle failure.

An identically constructed flight backup of Explorer 1 is on display in the Smithsonian Institution's National Air and Space Museum, Milestones of Flight Gallery in Washington, D.C., LC-26A was deactivated in 1963 and was designated for use as a museum in 1964, the Air Force Space and Missile Museum. Here too, a full-scale Explorer 1 is on display, but this one is a mock-up.

Gallery

Explorer I Characteristics.jpg |Explorer 1 statistics and orbital diagram Explorer I 02.jpg|Officials with Explorer 1 model at Redstone Arsenal, including Maj. Gen. John Medaris (3rd from left), Walter Haeussermann, Wernher von Braun and Ernst Stuhlinger Explorer1 people.jpg|William Hayward Pickering, James Van Allen, and Wernher von Braun display a full-scale model of Explorer 1 at a crowded news conference in Washington, D.C. after confirmation the satellite was in orbit. Explorer 1 During the Installation to Jupiter-C.jpg|Explorer 1 in spin test facility Jupier c explorer1 pad.jpg|Explorer 1 and Juno I booster in gantry at LC-26A Explorer 1 in Gantry.jpg|Close-up of Explorer 1 atop Juno I booster Launch of Jupiter C with Explorer 1.jpg|Launch of Explorer 1 on 1 February 1958 207457main antenna-331-2426a-516.jpg|Preliminary satellite tracking tests in a field near Jet Propulsion Laboratory 207469main_computers-p-163-500.jpg|Trajectory calculations were done by hand by this group of women.

References

References

1. Paul Dickson, ''Sputnik: The Launch of the Space Race'', Toronto: MacFarlane Walter & Ross, 2001, p. 190.
2. Yost, Charles W.. (6 September 1963). "Registration data for United States Space Launches". United Nations Office for Outer Space Affairs.
3. Matt Bille and Erika Lishock, The First Space Race: Launching the World's First Satellites, Texas A&M University Press, 2004, Chapter 5.
4. (21 October 1957). "Project Vanguard – Why It Failed to Live Up to Its Name".
5. (2 February 2005). "Sputnik and the Dawn of the Space Age". NASA.
6. (21 August 2023). "Explorer 1 Overview". NASA.
7. (9 July 2017). "Sputnik 2 and Laika". NASA.
8. McLaughlin Green, Constance. (1970). "Chapter 11: from Sputnik I to TV-3". NASA.
9. Williams, W. E. Jr.. (April 1960). "Space Telemetry Systems". Proceedings of the Institute of Radio Engineers.
10. "The First Transistors in Space – Personal Reflections by the Designer of the Cosmic Ray Instrumentation Package for the Explorer I Satellite". The Transistor Museum.
11. "Explorer-I and Jupiter-C". NASA.
12. (14 May 2020). "Cosmic-Ray Detector". NASA.
13. (28 October 2022). "Micrometeorite Detector". NASA.
14. Manring, Edward R.. (January 1959). "Micrometeorite Measurements from 1958 Alpha and Gamma Satellites". Planetary and Space Science.
15. Ley, Willy. (October 1968). "The Orbit of Explorer 1".
16. (14 May 2020). "Trajectory: Explorer-1 1958-001A". NASA.
17. "Solar System Exploration Explorer 1". NASA.
18. Zadunaisky, Pedro E.. (October 1960). "The Orbit of Satellite 456 Alpha (Explorer 1) during the First 10500 Revolutions". SAO Special Report.
19. Ley, Willy. (October 1968). "The Orbit of Explorer-1".
20. Efroimsky, Michael. (August 2001). "Relaxation of wobbling asteroids and comets – theoretical problems, perspectives of experimental observation". Planetary and Space Science.
21. Efroimsky, Michael. (March 2002). "Euler, Jacobi, and missions to comets and asteroids". Advances in Space Research.
22. Dubin, Maurice. (January 1960). "IGY Micrometeorite Measurements". Space Research – Proceedings of the First International Space Science Symposium.
23. J. Boehm, H.J. Fichtner and Otto A. Hoberg, [https://www.nasa.gov/sites/default/files/atoms/files/explorer_i_boehm_document.pdf EXPLORER SATELLITES LAUNCHED BY JUNO 1 AND JUNO 2 VEHICLES], NASA. {{PD-notice
24. Evelyn Boswell. (23 October 2011). "MSU's twin satellite to launch October 28 on NASA rocket". Space Science and Engineering Laboratory.
25. [http://www.afspacemuseum.org/displays/LC26blockhouse/ Launch Complex 26 Blockhouse] {{Webarchive. link. (25 April 2016 {{PD-notice)
26. [http://www.afspacemuseum.org/displays/ExplorerI/ Explorer I] {{Webarchive. link. (26 May 2016 {{PD-notice)
27. (2008-01-31). "The First Explorer".
28. "NASA / JPL - Ground Antenna". NASA.